Hostname: page-component-cd9895bd7-7cvxr Total loading time: 0 Render date: 2024-12-26T07:36:50.353Z Has data issue: false hasContentIssue false
  • English
  • Français

The development and structure of primary and secondary flow in a curved square duct

Published online by Cambridge University Press:  20 April 2006

P. Hille ,
R. Vehrenkamp  and
E. O. Schulz-Dubois
P. Hille
Affiliation:
Institute of Applied Physics, University of Kiel, F.R. Germany
R. Vehrenkamp
Affiliation:
Institute of Applied Physics, University of Kiel, F.R. Germany Present address: Lambda-Physik, D-3400 Göttingen, F.R. Germany.
E. O. Schulz-Dubois
Affiliation:
Institute of Applied Physics, University of Kiel, F.R. Germany
Get access Rights & Permissions [Opens in a new window]

Abstract

The development of laminar flow in a 180° section of a curved square duct (R/d = 6.45) was studied by laser-Doppler anemometry (LDA). The streamwise flow-velocity component Vϕ and the secondary flow component Vr were measured as a function of Dean number and of the azimuthal angle ϕ. The development of the streamwise flow component was found to be connected with a strong momentum transfer towards the outer wall between ϕ = 0° and ϕ = 60°, with a partial back-transfer of the momentum towards the duct centre (ϕ = 45°–108°), and with little further change of the momentum between ϕ = 108° and 180° near the outer wall. The measurements of the Vr component showed at least one vortex pair in the secondary flow. A second vortex pair with opposing sense of circulation was found to develop near the outer wall only for Dean numbers between 150 and 300, in agreement with numerical calculations. This second vortex pair was found in the region between ϕ = 108 and 171°. Between ϕ = 60 and 108° it was not possible to identify the second vortex pair in the developing flow. However, developing laminar-flow numerical calculations by Humphrey (1982) show that it also arises for K = 485 in a 180° square duct with R/d = 3.35 and Re = 890, and it is a function of inlet flow conditions. From the measured stream-function maximum of the second vortex pair it may be deduced that a curved duct with 180° (20 hydraulic diameters) bend angle is not sufficient to reach fully developed flow conditions at d/R = 1/6.45 and K = 226.

Type
Research Article
Information
Journal of Fluid Mechanics , Volume 151 , February 1985 , pp. 219 - 241
Copyright
© 1985 Cambridge University Press

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

Agrawal Y., Talbot, L. & Gong K.1978 Laser anemometer study of flow development in curved circular pipes. J. Fluid Mech. 85, 497–518.Google Scholar
Augustin H.1982 Realisierung einer nahezu idealen Laminarströmung im Rechteck-Kanal durch Schaffung geeigneter thermischer und hydrodynamischer Bedingungen. Diplomarbeit, Kiel.
Benjamin T. B.1978 Bifurcation phenomena in steady flows of a viscous fluid. I. Theory. II. Experiment Proc. R. Soc. Lond. A 359, 1–26, 27–43.Google Scholar
Berger S. A., Talbot, L. & Yao L. S.1983 Flow in curved pipes Ann. Rev. Fluid Mech. 15, 461–512.Google Scholar
Bertelsen, A. & Thorsen L. K.1982 An experimental investigation of oscillatory flow in pipe bends. J. Fluid Mech. 118, 269–284.Google Scholar
Cheng K. C., Hong, S. W. & Hwang G. J.1972 Buoyancy effects on laminar heat transfer in the thermal entrance region of horizontal rectangular channels with uniform wall heat flux for large Prandtl number fluid. Intl J. Heat Mass Transfer 15, 1819.Google Scholar
Cheng K. C, Lin, R. C. & Ou J. W.1976 Fully developed flow in curved rectangular channels Trans. ASME I: J. Fluids Engng 98, 41–48.Google Scholar
Chang S. M., Humphrey, J. A. C. & Modavi A.1983 Turbulent flow in a strongly curved U-bend and downstream tangent of square cross-sections. Physico-Chem. Hydrodyn. 4, 243–269.Google Scholar
Cummins, H. Z. & Pike E. R.1977 Photon Correlation Spectroscopy and Velocimetry. Plenum.
Dean W. R.1927 Note on the motion of fluid in a curved pipe Phil. Mag. (7) 4, 208–223.Google Scholar
Dean W. R.1928a Fluid motion in a curved channel Proc. R. Soc. Loud. A 121, 402–420.Google Scholar
Dean W. R.1928b The streamline motion of fluid in a curved pipe (second paper) Phil. Mag. (7) 5, 673–695.Google Scholar
Durst F., Melling, A. & Whitelaw J. H.1976 Principles and Practice of Laser-Doppler Anemometry. Academic.
Ghia, K. N. & Sokhey J. S.1977 Laminar incompressible viscous flow in curved ducts of rectangular cross-sections. Trans. ASME I: J. Fluids Engng 99, 640–648.Google Scholar
Hall P.1982 Centrifugal instabilities of circumferential flows in finite cylinders: the wide gap problem Proc. R. Soc. Lond. A 384, 359–379.Google Scholar
Hille P.1981 Zur Entwicklung von laminaren Strömungen in gekrümmten Kanälen. Diplom-arbeit, Kiel.
Hille P., Vehrenkamp, R. & Schulz-DuBois E. O.1983 Measurement of small secondary flow components by photon correlation velocimetry. Optica Acta 30, 139–153.Google Scholar
Humphrey J. A. C.1978 Numerical calculations of developing laminar flow in pipes of arbitrary curvature radius Can. J. Chem. Engng 56, 151–164.Google Scholar
Humphrey J. A. C., Chang, S. M. & Modavi A.1982 Developing turbulent flow in 180 bend and downstream tangent of square cross-sections. LBL Rep. 14844 (Berkeley).Google Scholar
Humphrey J. A. C., Taylor, A. M. K. & Whitelaw J. H.1977 Laminar flow in a square duct of strong curvature. J. Fluid Mech. 83, 509–527.Google Scholar
Joseph B., Smith, E. P. & Adler R. J.1975 Numerical treatment of laminar flow in helically coiled tubes of square cross-section. AIChE J. 21, 965–979.Google Scholar
Joseph D. D.1981 Hydrodynamic stability and bifurcation. In Hydrodynamic Instabilities and the Transition to Turbulence (ed. H. L. Swinney & J. P. Gollub), pp. 27–76. Springer.
Mcconalogue, D. J. & Srivastava R. S.1968 Motion of a fluid in a curved tube Proc. R. Soc. Lond. A 307, 37–53.Google Scholar
Mori, Y. & Futagami K.1967 Forced convective heat transfer in uniformly heated horizontal tubes. Intl J. Heat Mass Transfer 10, 1801.Google Scholar
Mori Y., Uchida, V. & Ukon T.1971 Forced convective heat transfer in a curved channel with a square cross section. Intl J. Heat Mass Transfer 14, 178–1805.Google Scholar
Mullin, T. & Greated C. A.1980 Oscillatory flow in curved pipes. J. Fluid Mech. 98, 383–416.Google Scholar
Mullin T., Pfister, G. & Lorenzen A.1982 New observations on hysteresis effects in Taylor—Couette flow Phys. Fluids 25, 1134–1136.Google Scholar
Nandakumar, K. & Masliyah J. M.1982 Bifurcation in steady laminar flow through curved tubes. J. Fluid Mech. 119, 475–490.Google Scholar
Olson D. E.1971 Fluid mechanics relevent to respiration-flow within curved or elliptical tubes and bifurcating systems. Ph.D. thesis, University of London.
Olson, D. E. & Snyder B.1982 The growth of swirl in curved circular pipes. Phys. Fluids 26, 347–349.Google Scholar
Ou J. W., Chen, K. C. & Lin R. C.1974 Natural convection effects in horizontal rectangular channels with uniform wall temperature for large Pr. Intl J. Heat Mass Transfer 17, 835–843.Google Scholar
Schlichting H.1934 Laminare Kanaleinlaufströmung. Z. angew. Math. Mech. 14, 368–373.Google Scholar
Scheel, H. J. & Schulz-DuBois E. O.1982 The role of hydrodynamics in crystal growth from high-temperature solutions. In Convective Transport and Instability Phenomena (ed. J. Zierep & H. Oertel), pp. 491–513. Braun.
Singh P.1974 Entry flow in a curved pipe. J. Fluid Mech. 65, 517–539.Google Scholar
Smith F. T. P.1976 Fluid flow into a curved pipe Proc. R. Soc. Lond. A 351, 71–87.Google Scholar
Talbot, L. & Gong K.1983 Pulsatile entrance flow in a curved pipe. J. Fluid Mech. 127, 1–25.Google Scholar
Taylor A. M. K. P., Whitelaw, J. J. & Yianneskis M.1982 Curved ducts with strong secondary motion - velocity measurements of developing laminar and turbulent flow. Trans. ASME I: J. Fluids Engng 104, 350–359.Google Scholar
Vehrenkamp R.1980 Nach dem Photonen-Korrelations-Verfahren durchgeführte Laser-Doppler-Messungen zur Wirbelentstehung in gekrümmten Kanälen. Dissertation, Kiel.
Vehrenkamp, R. & Pfister G.1980 Advances in the analysis of weak secondary flows. Proc. Intl Conf. on Long Range and Short Range Optical Velocity Measurements. St Louis, France.
Vehrenkamp R.1980 Investigations of hydrodynamic instabilities by photon correlation anemometry. Proc. 4th Intl Conf. on Photon Correlation Techniques in Fluid Mechanics, Stanford.
Yao, L. S. & Berger S. A.1975 Entry flow in a curved pipe J. Fluid Mech. 67, 177–196.Google Scholar