Hostname: page-component-78c5997874-v9fdk Total loading time: 0 Render date: 2024-11-10T10:38:41.606Z Has data issue: false hasContentIssue false
  • English
  • Français

Metastability in hydrogenated nanocrystalline silicon solar cells

Published online by Cambridge University Press:  03 March 2011

Guozhen Yue ,
Baojie Yan ,
Gautam Ganguly ,
Jeffrey Yang  and
Subhendu Guha
Guozhen Yue*
Affiliation:
United Solar Ovonic LLC, Troy, Michigan 48084
Baojie Yan
Affiliation:
United Solar Ovonic LLC, Troy, Michigan 48084
Gautam Ganguly
Affiliation:
United Solar Ovonic LLC, Troy, Michigan 48084
Jeffrey Yang
Affiliation:
United Solar Ovonic LLC, Troy, Michigan 48084
Subhendu Guha
Affiliation:
United Solar Ovonic LLC, Troy, Michigan 48084
*
a) Address all correspondence to this author. e-mail: gyue@uni-solar.com This paper was selected as the Outstanding Meeting Paper for the 2006 MRS Spring Meeting Symposium A Proceedings, Vol. 910.
Get access

Abstract

Light-induced metastability in hydrogenated nanocrystalline silicon (nc-Si:H) single-junction solar cells was studied systematically. First, we observed no light-induced degradation when the photon energy was lower than the band gap of the amorphous phase; degradation occurred when the energy was higher than the band gap in the amorphous phase. The light-induced degradation could be annealed away at an elevated temperature. We concluded that the light-induced defect generation occurred mainly in the amorphous phase. Second, forward current injection did not degrade the nc-Si:H cell performance. However, a reverse bias during light soaking enhanced the degradation. Third, the nc-Si:H cells made with an optimized hydrogen dilution profile showed minimal degradation although these cells had a high amorphous volume fraction. This indicated that the amorphous volume fraction was not the only factor determining the degradation. Other factors also played important roles in the nc-Si:H stability.

Keywords

DefectsElectronic structureSi
Type
Outstanding Meeting Paper
Information
Journal of Materials Research , Volume 22 , Issue 5 , May 2007 , pp. 1128 - 1137
Copyright
Copyright © Materials Research Society 2007

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1Staebler, D.L. and Wronski, C.R.: Reversible conductivity changes in discharge-produced amorphous Si. Appl. Phys. Lett. 31, 292 (1977).Google Scholar
2Meier, J., Flückiger, R., Keppner, H., and Shah, A.: Complete microcrystalline p-i-n solar cell-crystalline or amorphous cell behavior? Appl. Phys. Lett. 65, 860 (1994).Google Scholar
3Yamamoto, K.: Very thin film crystalline silicon solar cells on glass substrate fabricated at low temperature. IEEE Trans. Electron Dev. 46, 2041 (1999).CrossRefGoogle Scholar
4Klein, S., Finger, F., Carius, R., Dylla, T., Rech, B., Grimm, M., Houben, L., and Stutzmann, M.: Intrinsic microcrystalline silicon prepared by hot-wire chemical vapour deposition for thin film solar cells. Thin Solid Films 430, 202 (2003).CrossRefGoogle Scholar
5Meillaud, F., Vallat-Sauvain, E., Niquille, X., Dubey, M., Bailat, J., Shah, A., and Ballif, C.: Light-induced degradation of thin film amorphous and microcrystalline silicon solar cells, in Proceeding of the 31st IEEE Photovoltaic Specialists Conference, (IEEE, New York, 2005), p. 150.Google Scholar
6Gordijn, A., Francke, J., Hodakova, L., Rath, J.K., and Schropp, R.E.I.: Influence of pressure and plasma potential on high growth rate microcrystalline silicon grown by VHF PECVD, in Amorphous and Nanocrystalline Silicon Science and Technology—2005 edited by Collins, R.W., Taylor, P.C., Kondo, M., Carius, R. and Biswas, R. (Mater. Res. Soc. Symp. Proc. 862, Warrendale, PA, 2005), p. 87.Google Scholar
7Fritzsche, H.: Early research on amorphous silicon: Errors and missed opportunities, in Amorphous and Heterogeneous Silicon Thin Films—2000 edited by Collins, R.W., Branz, H.M., Stutzmann, M., Guha, S. and Okamoto, H. (Mater. Res. Soc. Symp. Proc. 609, Warrendale, PA, 2001), p. A17.1.Google Scholar
8Branz, H.: Hydrogen diffusion and mobile hydrogen in amorphous silicon. Phys. Rev. B60, 7725 (1999).CrossRefGoogle Scholar
9Williamson, D. (private communication).Google Scholar
10Yan, B., Yue, G., Owens, J.M., Yang, J., and Guha, S.: Light-induced metastability in hydrogenated nanocrystalline silicon solar cells. Appl. Phys. Lett. 85, 1925 (2004).Google Scholar
11Yue, G., Yan, B., Yang, J., and Guha, S.: Effect of electrical bias on metastability in hydrogenated nanocrystalline silicon solar cells. Appl. Phys. Lett. 86, 092103 (2005).CrossRefGoogle Scholar
12Yue, G., Yan, B., Yang, J., and Guha, S.: Enhancement of light-induced degradation under reverse bias in hydrogenated nanocrystalline silicon solar cells. J. Appl. Phys. 98, 074902 (2005).Google Scholar
13Yan, B., Yang, J., and Guha, S.: Effect of hydrogen dilution on the open-circuit voltage of hydrogenated amorphous silicon solar cells. Appl. Phys. Lett. 83, 782 (2003).Google Scholar
14Yan, B., Yang, J., and Guha, S.: Temperature dependence of dark current-voltage characteristics of hydrogenated amorphous and nanocrystalline silicon based solar cells, in Amorphous and Polycrystalline Thin-Film Silicon Science and Technology—2006, edited by Wagner, S., Chu, V., Atwater, H.A. Jr., K. Yamamoto, and H-W. Zan (Mater. Res. Soc. Symp. Proc. 910, Warrendale, PA, 2007), p. A26-02.Google Scholar
15Yang, L., Chen, L., Hou, J.Y., and Li, Y.M.: The mechanism for defect generation studied by photodegradation of a-Si:H solar cells under electrical bias, in Amorphous Silicon Technology—1992, edited by Thompson, M.J., Hamakawa, Y., LeComber, P.G., Madan, A. and Schiff, E. (Mater. Res. Soc. Symp. Proc. 258, Pittsburgh, PA, 1992), p. 365.Google Scholar
16Yang, J., Lord, K., Yan, B., Banerjee, A., and Guha, S.: Correlation of the open-circuit voltage enhancement of heterogenous silicon solar cells and the Staebler-Wronski effect, in Proc. 29th IEEE Photovoltaic Specialists Conference (IEEE, New York, 2002), p. 1094.Google Scholar
17Banerjee, A., Xu, X., Yang, J., and Guha, S.: Carrier collection losses in amorphous silicon and amorphous silicon-germanium alloy solar cells. Appl. Phys. Lett. 67, 2975 (1995).Google Scholar
18Yan, B., Yue, G., Yang, J., Guha, S., Williamson, D.L., Han, D., and Jiang, C.: Hydrogen dilution profiling for hydrogenated microcrystalline silicon solar cells. Appl. Phys. Lett. 85, 1955 (2004).Google Scholar
19Shah, A.V., Meier, J., Vallat-Sauvain, E., Wyrsch, N., Kroll, U., Droz, C., and Graf, U.: Material and solar cell research in microcrystalline silicon. Sol. Energy Mater. Sol. Cells. 78, 469 (2003).Google Scholar
20Vallat-Sauvain, E., Kroll, U., Meier, J., Shah, A., and Pohl, J.: Evolution of the microstructure in microcrystalline silicon prepared by very high frequency glow-discharge using hydrogen dilution. J. Appl. Phys. 87, 3137 (2000).Google Scholar
21Yan, B., Jiang, C-S., Teplin, C.W., Moutinho, H.R., Al-Jassim, M.M., Yang, J., and Guha, S.: Local current flow in amorphous and nanocrystalline mixed-phase silicon solar cells. J. Appl. Phys. 101, 033711 (2007).CrossRefGoogle Scholar