Hostname: page-component-cd9895bd7-dzt6s Total loading time: 0 Render date: 2024-12-28T06:30:25.615Z Has data issue: false hasContentIssue false
  • English
  • Français

Oxidation Behavior of Cu60Zr30Ti10 Bulk Metallic Glass

Published online by Cambridge University Press:  01 June 2005

C.Y. Tam  and
C.H. Shek
C.Y. Tam
Affiliation:
Department of Physics and Materials Science, City University of Hong Kong, Kowloon Tong, Hong Kong
C.H. Shek*
Affiliation:
Department of Physics and Materials Science, City University of Hong Kong, Kowloon Tong, Hong Kong
*
a) Address all correspondence to this author. e-mail: apchshek@cityu.edu.hk
Get access

Abstract

The oxidation kinetics of Cu60Zr30Ti10 bulk metallic glass and its crystalline counterpart were studied in oxygen environment over the temperature range of 573–773 K. The oxidation kinetics, measured with thermogravimetric analysis, of the metallic glass follows a linear rate law between 573 and 653 K and a parabolic rate law between 673 and 733 K. It was also found that the oxidation activation energy of metallic glass is lower than that of its crystalline counterpart. The x-ray diffraction pattern showed that the oxide layer is composed of Cu2O, CuO, ZrO2, and metallic Cu. Cu enrichment on the topmost oxide layer of the metallic glass oxidized at 573 K was revealed by x-ray photoelectron spectroscopy while there was a decrease in Cu content in the innermost oxide layer. The oxide surface morphologies observed from scanning electron microscopy showed that ZrO2 granules formed at low temperatures while whiskerlike copper oxides formed at higher temperatures.

Keywords

AmorphousOxidation/annealingX-ray photoelectron spectroscopy (XPS)
Type
Articles
Information
Journal of Materials Research , Volume 20 , Issue 6 , June 2005 , pp. 1396 - 1403
Copyright
Copyright © Materials Research Society 2005

Access options

Get access to the full version of this content by using one of the access options below. (Log in options will check for institutional or personal access. Content may require purchase if you do not have access.)

References

REFERENCES

1Inoue, A., Zhang, W., Zhang, T. and Kurosaka, K.: High-strength Cu-based bulk glassy alloys in Cu–Zr–Ti and Cu–Hf–Ti ternary systems. Acta Mater. 49, 2645 (2001).CrossRefGoogle Scholar
2Inoue, A., Zhang, W., Zhang, T. and Kurosaka, K.: Cu-based bulk glassy alloys with high tensile strength of over 2000 MPa. J. Non-Cryst. Solids 304, 200 (2002).CrossRefGoogle Scholar
3Inoue, A.: Stabilization and high strain-rate superplasticity of metallic supercooled liquid. Mater. Sci. Eng. A 267, 171 (1999).CrossRefGoogle Scholar
4Dhawan, A., Raetzke, K., Faupel, F. and Sharma, S.K.: Air oxidation of Zr65Cu17.5Ni10Al7.5 its amorphous and supercooled liquid states, studied by thermogravimetric analysis. Phys. Status Solidi A 199, 431 (2003).CrossRefGoogle Scholar
5Jastrow, L., Köster, U. and Meuris, M.: Catastrophic oxidation of Zr-TM (noble metals) glasses. Mater. Sci. Eng. A 375–377, 440 (2004).CrossRefGoogle Scholar
6Kim, M.C. and Mcnallan, M.J.: Oxidation and crystallization studies of Fe–22.5Al–10Zr rapidly solidified metallic glass ribbons. Mater. Sci. Eng. A 134, 1078 (1991).CrossRefGoogle Scholar
7Wei, G. and Cantor, B.: The oxidation behavior of amorphous and crystalline Fe78Si9B13. Acta Metall. 36, 2293 (1988).CrossRefGoogle Scholar
8Dark, A.M., Wei, G. and Cantor, B.: The oxidation behavior of some cobalt-based amorphous-alloys. Mater. Sci. Eng. 99, 533 (1988).CrossRefGoogle Scholar
9Wei, G. and Cantor, B.: The oxidation behaviour of amorphous alloy Fe40Ni40P14B6. Acta Metall. 36, 167 (1988).CrossRefGoogle Scholar
10Köster, U., Zander, D., Triwikantoro, , Rüdiger, A. and Jastrow, L.: Environmental properties of Zr-based metallic glasses and nanocrystalline alloys. Scripta Mater. 44, 1649 (2001).CrossRefGoogle Scholar
11Kiene, M., Strunskus, T., Hasse, G. and Faupel, F. Oxide formation on the bulk metallic glass Zr46,75Ti8.25Cu7.5Ni10Be27.5, in Bulk Metallic Glasses, edited by Johnson, W.L., Inoue, A., and Liu, C.T. (Mater. Res. Soc. Symp. Proc. 554, Warrendale, PA, 1999), p. 167.Google Scholar
12Sharma, S.K., Strunskus, T., Ladebusch, H. and Faupel, F.: Surface oxidation of amorphous Zr65Cu17.5Ni10Al7.5 and Zr46.75Ti8.25Cu7.5Ni10Be27.5. Mater. Sci. Eng. A 304–306, 747 (2001).CrossRefGoogle Scholar
13Kai, W., Hsieh, H.H., Nieh, T.G. and Kawamura, Y.: Oxidation behavior of a Zr–Cu–Al–Ni amorphous alloy in air at 300–425 °C. Intermetallics 10, 1265 (2002).CrossRefGoogle Scholar
14Kimura, H.M., Asami, K., Inoue, A. and Masumoto, T.: The oxidation of amorphous Zr-base binary alloys in air. Corros. Sci. 35, 909 (1993).CrossRefGoogle Scholar
15Kilo, M., Hund, M., Sauer, G., Baiker, A. and Wokaun, A.: Reaction induced surface segregation in amorphous CuZr, NiZr and PdZr alloys—An XPS and SIMS depth profiling study. J. Alloy Compds. 236, 137 (1996).CrossRefGoogle Scholar
16Kudelski, A., Janik-Czachor, M., Bukowska, J., Pisarek, M. and Szummer, A.: Effect of ageing in air on morphology and surface-enhanced Raman scattering (SERS) activity of Cu-based amorphous alloys. Mater. Sci. Eng. A 326, 364 (2002).CrossRefGoogle Scholar
17Triwikantoro, , Toma, D., Meuris, M. and Köster, U.: Oxidation of Zr-based metallic glasses in air. J. Non-Cryst. Solids 250–252, 719 (1999).CrossRefGoogle Scholar
18Schneider, S., Sun, X., Nicolet, M-A. and Johnson, W.L. Diffusion, oxidation, and nucleation of crystalline phases in the glass-forming system ZrNiAl, in Science and Technology of Rapid Solidification and Processing, edited by Otooni, M.A. (NATO ASI Series 278, Dordrecht, The Netherlands, and Boston, MA, 1995), p. 317.CrossRefGoogle Scholar
19Kittel, C.: Introduction to Solid State Physics, 7th ed. (Wiley, New York, 1996), p. 78.Google Scholar
20Lide, D.R.: CRC Handbook of Chemistry and Physics, 84th ed. (CRC Press, Boca Raton, FL, 2003), pp. 9–76.Google Scholar
21Barin, I.: Thermochemical Data of Pure Substances, 2nd ed. (VCH, Weinheim, New York, 1993), pp. 483, 485, 1067, 1544, 1546, 1734.Google Scholar
22Wong, C.H. and Shek, C.H.: Difference in crystallization kinetics of Zr41Ti14Cu12.5Ni10Be22.5 bulk metallic glass under different oxidizing environments. Intermetallics 12, 1257 (2004).CrossRefGoogle Scholar
23Hunderi, O. and Bergersen, R.: On the thermal oxidation kinetics of two metallic glasses. Corros. Sci. 22, 135 (1982).CrossRefGoogle Scholar
24Bradford, S.A.: ASM Handbook, Vol. 13 (ASM International, Materials Park, OH, 1990), p. 64.Google Scholar
25Cullity, B.D.: Elements of X-ray Diffraction, 2nd ed. (Addison-Wesley, Reading, MA, 1978), p. 102.Google Scholar
26Sun, X., Schneider, S., Geyer, U., Johnson, W.L. and Nicolet, M-A.: Oxidation and crystallization of an amorphous Zr60Al15Ni25 alloy. J. Mater. Res. 11, 2738 (1996).CrossRefGoogle Scholar
27Bradford, S.A.: ASM Handbook, Vol. 13 (ASM International, Materials Park, OH, 1990), p. 68.Google Scholar
28Park, J-H. and Natesan, K.: Oxidation of copper and electronic transport in copper oxides. Oxid. Met. 39, 411 (1993).CrossRefGoogle Scholar
29Maciejewski, M. and Baiker, A.: Oxidation and crystallization behavior of amorphous Ni64Zr36 alloy. J. Chem. Soc., Faraday Trans. 1 86, 843 (1990).CrossRefGoogle Scholar
30Yamasaki, M., Nabazaki, H., Asami, K. and Hashimoto, K.: Oxidation behavior of amorphous Ni–Zr and Ni–Zr–Sm alloys. J. Electrochem. Soc. 147, 4502 (2000).CrossRefGoogle Scholar